Vehicles 15 years and under that have travelled less than 200,000 klms at warranty purchase.

Engine

Engine block, pistons, piston rings, gudgeon pins and bushes, connecting rods, main bearings, big end bearings, crankshaft, camshaft, camshaft bearings, cam followers, valve guides, valve stems, valve rockers, valve springs, oil pump, timing chain and timing gears.

Gearbox / Transmission

All internally lubricated parts in the transmission case, torque converter and transfer case.

Differential

All internally lubricated parts within the differential case

Turbo / Super Charger

Impellers and bearings

ABS Brake System

ABS electronic module, ABS actuator and wheel sensors

Air Conditioning

Compressor, compressor clutch, dual zone evaporator and condenser

Brakes

Power booster, master cylinder, calipers, meteal brake lines and proportioning valve

Clutch

Master cylinder and slave cylinder

Computers

Engine controle module (ECM/ECU) and cruise control module (CCM)

Cooling System

Water pump, cooling fan and fan clutch

Cylinder Head and Gasket

Cylinder head and head gasket

Driveshaft and Universals

Drive shaft, tail shaft, constant velocity and universal joints

Electrical

Starter motor, alternator, voltage regulator and windscreen wiper motor

Fuel System

Fuel injectors, fuel pump, diesel injector pump and metal delivery lines

Ignition System

Fuel injectors, fuel pump, diesel injector pump and metal delivery lines

Power Windows

Power window motors and window regulators

Radiator

Engine cooling radiator

Steering

All internally libricated parts within the manual steering box, power steering box, steering rack and power steering pump

Suspension

Coil and leaf springs, torsion bars and sway bars

Transmission Computer

Transmission control module (TCM)

Coverage: Australia wide

 Per claim limit:

Engine & Gearbox – $3000 

Other Listed Components – $1250

Unlimited Claims

Unlimited Klms

We will reimburse you up to $150 per day up to the maximum Claim Limit listed below for accommodation paid by you and reasonably incurred, if the Vehicle is immobilised for more than 1 day and the failure occurs more than 100 kilometres from your usual place of residence.

We will reimburse you up to $100 per day up to the maximum Claim Limit listed below for car hire paid by you and reasonably incurred, if the Vehicle is immobilised for more than 2 days. Please note: This coverage includes commercial car hire only and, will require a valid tax invoice from the car hire company. This coverage also does not include other modes of transport such as Taxi’s, Uber, Train, other forms of public transport.

If another Listed Component suffers a Failure as a consequence of the Original Failure we will approve up to $350 per claim.

No Excess

If you sell the vessel you can apply to transfer this Warranty to a new owner, provided the transfer occurs within 7 days of the date of sale or transfer of ownership of the vessel. It is important to follow these steps to successfully transfer the Warranty

30 days

If you cancel your Warranty on or before 30 days of the Purchase Date and no benefits have been paid out you will receive a full refund of the premium paid.

Vehicles Less than 225,000klms or 15 years of age at time of warranty purchase

Engine

Engine block (if damaged by internal components), balance shaft, balance shaft bearings, camshafts, camshaft bearings, internal bushes, connecting
rods, big end bearings, crankshaft, crankshaft main bearings, oil pressure relief valve, oil pump, cylinder wrist pins, piston rings, gudgeon pins,
pistons, crank thrust bearings, air pump, throttle cables, meshing timing gears only..

Automatic Gearbox / Transmission

Internal lubricated components including clutches, bands, bushes, planetary gear set, bearings, solenoids, clutch drums, transmission pump, valve
body, apply pistons, shafts, external mechanical components including inhibitor switch, speedo transducer, vehicle speed sensor, torque converter,
transfer case and transmission case if damaged by a covered component (specifically excluding selespeed systems) only.

Manual Gearbox / Transmission

Internal lubricated components including input shaft, output shaft, main shaft, cluster gearset, syncro rings, syncro hubs, internal bearings, roller
bearings, internal thrust bearings, selector forks, internal selector arms, external mechanical components, pedal box, speedo transducer, vehicle
speed sensor, reverse light switch, transfer case linkages, transfer case and transmission case if damaged by a covered component (specifically
excluding selespeed systems) only.

Differential

The internal lubricated parts only, crown wheel and pinion, pinion bearings, carrier bearings, hemisphere, axle hub bearings, axle shafts, bushes,
limited slip clutch pack only.

Turbo / Super Charger

Turbo impeller, internal bushings and bearings, turbo housing, turbine wheel, wastegate, turbo actuator (this cover only applies to factory-fitted
turbochargers) only.

ABS Brake System

ABS actuators, electronic module, wheel speed sensors, abs accumulator, steering angle sensor only.

Air Conditioning

Compressor, compressor bearings, compressor clutch, condenser, evaporator, air conditioning pressure switch (specifically excluding gas, leakages,
pipes, hoses, thermostat, receiver dryer and tx valves) only.

Brakes

Brake booster, brake master cylinder, front and rear brake calipers, brake caliper slide pins, proportioning valve, brake accumulator only.

Clutch

Clutch Covered Components are:
Clutch master cylinder, slave cylinder, clutch fork, clutch cable (specifically excluding clutch plate, pressure plate, throwout bearing) only.

Computers

Engine controle module (ECM/ECU) and cruise control module (CCM)

Cooling System

Water pump (impeller shaft, bearing and bushes), electric engine cooling fan, viscous fan hub, fan blades, thermostat, heater tap, coolant level
sensor only.

Cylinder Head and Gasket

Cylinder head, lash adjusters, inlet valves, exhaust valves, pre-combustion chambers, valve guides, valve seats, valve springs, valve collets and
retainers, hydraulic lifters, rocker shaft only.

Driveshaft and Universals

Drive shafts, universal joints, centre bearings, tail shafts, slip joints, tail shaft coupling, cv joints (specifically excluding cv dust boot) only.

Electrical

Starter motor, alternator, voltage regulator, windscreen wiper motor, rear window wiper motor, windscreen washer pump only.

Fuel System

Electrical and mechanical fuel pumps, diesel injector pump, fuel pressure regulator, map sensor, airflow meter, oxygen sensor, suction control valve,
fuel pump relay (specifically excluding fuel injectors and injection service items) only.

Ignition System

Ignition module, ignition coil, crank angle sensor, hall effect sensor, cam position sensor, knock sensor, ignition amplifier, throttle positioning sensor,
ignition switch, push-button starter switch only.

Power Windows

Power window motor, power window master switch, power window regulators (specifically excluding sunroofs) only.

Radiator

Engine cooling radiator, radiator expansion/header tank, coolant overflow bottle only.

Steering

Power steering pump, power steering rack and pinion, power steering box (specifically excludes rack ends and rack boots) only.

Suspension

Coil and leaf springs, torsion bars and sway bars

Transmission Computer

Transmission computer, power train control module only.

Engine Computer

Engine control module, cruise control actuators and cruise control sensors only.

Electronics and Electro-Mechanical 

Electric boot release, fuel flap release solenoid, rear demister switch, power mirror switch, hazard light switch, headlight switch, mirror motors,
windscreen wiper arms and linkages, interior light switch, courtesy light switch only.

Other Covered Components

Cylinder head gaskets and seals will be replaced only when such replacement is required in the normal course of repair of a covered component
only.

Coverage: Australia wide

 Per claim limit:

Engine & Gearbox – $3000 

Other Listed Components – $3000

Unlimited Claims

Unlimited Klms

(Benefit Limit: Up to $100 per Claim) – Reimbursement up to the Benefit Limit for emergency accommodation,
arrangements and costs in the event of a covered major vehicle breakdown where You are more than 400 km’s from Your registered residence and the
covered breakdown takes more than 48 hours to repair.

(Benefit Limit: Up to $100 per Claim) – Reimbursement up to the Benefit Limit for car hire costs in the event of a covered major
vehicle breakdown where You are more than 400 km’s from Your registered residence and taking more than 48 hours to repair.

X

No Excess

This Mechanical Breakdown Warranty cannot be transferred to another motor vehicle or motor vehicle dealer.
If You are not in breach of the terms of this Mechanical Breakdown Warranty You may transfer the benefits of this Mechanical Breakdown Warranty to
a new owner of the Motor Vehicle within 7 days.

30 days

You may cancel this Mechanical Breakdown Warranty for any reason within 30 days from the Application Date of the Product. This is known as the “Cooling Off Period”.